fs: new standard-bore replacement cylinder, standard piston and ring
-
- Posts: 125
- Joined: Mon Nov 05, 2007 12:13 pm
battery question
Last year I checked my battery for the first time in 3 years and found
it almost completely out of water. It started fine so I saw no reason
to check it before. I filled it and all was good. This year I decided
it might be best to replace it. I removed the 4 year old battery and
again, it was almost empty. Its been starting just fine, has not been
dumped and has about 2000 miles on it since I last filled it. Is this
normal? Might I have damaged the battery? This was a conventional wet
type battery.
-
- Posts: 639
- Joined: Sat Dec 03, 2005 11:36 am
battery question
--- In DSN_KLR650@yahoogroups.com, "mikeypep" wrote:
Bad move, Mikey. The KLR is infamous for boiling its battery fluid out. Speculation is that the voltage regulator allows too much voltage to get to the battery, but if you run a KLR at high speeds, it can boil the fluid out within 500 miles.> Last year I checked my battery for the first time in 3 years and found > it almost completely out of water. It started fine so I saw no reason > to check it before.
If it's still starting it obviously hasn't warped the plates or otherwise shorted out yet, so no, the battery hasn't been damaged. My suggestion, however, would be to get an AGM "dry" battery (check the FAQ at the bottom of this message for some part numbers). That way you don't have to worry about its waterlevel. 4 years is a long lifetime for a battery, especially one that has been consistently neglected, and it's due to decide any moment now that it isn't going to hold a charge.> it might be best to replace it. I removed the 4 year old battery and > again, it was almost empty. Its been starting just fine, has not been > dumped and has about 2000 miles on it since I last filled it. Is this > normal? Might I have damaged the battery?
-
- Posts: 326
- Joined: Mon Oct 16, 2000 5:01 pm
battery question
mikeypep wrote:
Interesting as my 2008, less than a year old, was dead and found it to be bone dry, I had checked it a few weeks before as it was dead but thought due to NON use it had not simply charged, I took it out and looked at it and believed it had liquid in there but no so when I took it back to the dealer. Here is TX the heat is bad on batteries and it's stored inside the garage, and it's really hot in the summer!> > Last year I checked my battery for the first time in 3 years and found > it almost completely out of water. It started fine so I saw no reason > to check it before. I filled it and all was good. This year I decided > it might be best to replace it. I removed the 4 year old battery and > again, it was almost empty. Its been starting just fine, has not been > dumped and has about 2000 miles on it since I last filled it. Is this > normal? Might I have damaged the battery? This was a conventional wet > type battery. > >
-
- Posts: 105
- Joined: Mon Mar 14, 2011 10:46 pm
battery question
Hello friends,
I have a used 2007 battery that's been sitting without any acid for a few months. Can I just buy the acid, fill up and recharge or do I need to buy a whole new battery? Will it work ok?
Regards,
--
David Z mobile: 646-267-1109 poisonpartyband.com
-
- Posts: 54
- Joined: Tue Jan 16, 2007 9:37 am
battery question
#ygrps-yiv-1030648267 .ygrps-yiv-1030648267ygrp-photo-title { OVERFLOW:hidden;FONT-SIZE:smaller;HEIGHT:15px;WIDTH:75px;TEXT-ALIGN:center;CLEAR:both;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267ygrp-photo { BORDER-TOP:black 1px solid;HEIGHT:62px;BORDER-RIGHT:black 1px solid;WIDTH:62px;BACKGROUND-REPEAT:no-repeat;BORDER-BOTTOM:black 1px solid;BACKGROUND-POSITION:center 50%;BORDER-LEFT:black 1px solid;BACKGROUND-COLOR:white;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267photo-title A { TEXT-DECORATION:none;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267photo-title A:active { TEXT-DECORATION:none;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267photo-title A:hover { TEXT-DECORATION:none;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267photo-title A:visited { TEXT-DECORATION:none;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267attach-table DIV.ygrps-yiv-1030648267attach-row { CLEAR:both;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267attach-table DIV.ygrps-yiv-1030648267attach-row DIV { FLOAT:left;} #ygrps-yiv-1030648267 P { OVERFLOW:hidden;PADDING-BOTTOM:3px;PADDING-TOP:15px;PADDING-LEFT:0px;CLEAR:both;PADDING-RIGHT:0px;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267ygrp-file { WIDTH:30px;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267attach-table DIV.ygrps-yiv-1030648267attach-row DIV DIV A { TEXT-DECORATION:none;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267attach-table DIV.ygrps-yiv-1030648267attach-row DIV DIV SPAN { FONT-WEIGHT:normal;} #ygrps-yiv-1030648267 DIV.ygrps-yiv-1030648267ygrp-file-title { FONT-WEIGHT:bold;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp { BORDER-TOP:#d8d8d8 1px solid;FONT-FAMILY:Arial;BORDER-RIGHT:#d8d8d8 1px solid;BORDER-BOTTOM:#d8d8d8 1px solid;PADDING-BOTTOM:0px;PADDING-TOP:0px;PADDING-LEFT:10px;MARGIN:10px 0px;BORDER-LEFT:#d8d8d8 1px solid;PADDING-RIGHT:10px;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp HR { BORDER-TOP:#d8d8d8 1px solid;BORDER-RIGHT:#d8d8d8 1px solid;BORDER-BOTTOM:#d8d8d8 1px solid;BORDER-LEFT:#d8d8d8 1px solid;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp #ygrps-yiv-1030648267hd { FONT-SIZE:85%;FONT-WEIGHT:700;COLOR:#628c2a;MARGIN:10px 0px;LINE-HEIGHT:122%;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp #ygrps-yiv-1030648267ads { MARGIN-BOTTOM:10px;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp .ygrps-yiv-1030648267ad { PADDING-BOTTOM:0px;PADDING-TOP:0px;PADDING-LEFT:0px;PADDING-RIGHT:0px;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp .ygrps-yiv-1030648267ad P { MARGIN:0px;} #ygrps-yiv-1030648267 #ygrps-yiv-1030648267ygrp-mkp .ygrps-yiv-1030648267ad A { TEXT-DECORATION:none;COLOR:#0000ff;} On Fri, 7 Oct 2016 11:33:59 -0400 "david zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: Hello friends, I have a used 2007 battery that's been sitting without any acid for a few months. Can I just buy the acid, fill up and recharge or do I need to buy a whole new battery? Will it work ok?
Regards, -- David Z
<><><><><> <><><><><> David, Once a battery has been put into service you only ever add distilled water. So it is time for a new battery. Best,
Jeff Saline
The Beautiful Black Hills of South Dakota
75 R90/6, 03 KLR650
. . . . . . .
____________________________________________________________
[b]How To Fix Your Fatigue (Do This Every Day)[/b]
gundrymd.com
http://thirdpartyoffers.juno.com/TGL3142/57f803c6946733c636b2st04vuc
[img]https://ec.yimg.com/ec?url=https%3A%2F% ... qIqtAA--~E[/img]
-
- Posts: 32
- Joined: Mon Nov 18, 2002 10:32 pm
battery question
But wait, he said the battery has no acid in it. What's the full story? Is it *dry*? Was the original acid dumped? Was the battery rinsed? If the plates aren't shot (still lead and clean-ish), maybe it could be resurrected. If it's a matter of all the water evaporating from the original acid, then the battery is toast.
Mark
On Fri, Oct 7, 2016 at 4:19 PM, salinej1@... [DSN_KLR650] DSN_KLR650@yahoogroups.com> wrote: [u][/u] On Fri, 7 Oct 2016 11:33:59 -0400 "david zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: Hello friends, I have a used 2007 battery that's been sitting without any acid for a few months. Can I just buy the acid, fill up and recharge or do I need to buy a whole new battery? Will it work ok? Regards, -- David Z <><><><><> <><><><><> David, Once a battery has been put into service you only ever add distilled water. So it is time for a new battery. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . ______________________________ ______________________________ [b]How To Fix Your Fatigue (Do This Every Day)[/b] gundrymd.com http://thirdpartyoffers.juno. com/TGL3142/ 57f803c6946733c636b2st04vuc [img]https://ec.yimg.com/ec?url=https%3A%2F% ... KMC3jw--~E[/img]
-
- Posts: 105
- Joined: Mon Mar 14, 2011 10:46 pm
battery question
The bike was stolen from me and was sitting for a few months. When I got it back there was nothing inside the battery. I filled it up with distilled water, charged it for 3days and the bike fired up. 3 weeks passed. After riding the bike to the DMV Inspection site for a new title the battery died. I jumped it from a car and passed the test.
I'm suspecting that the bike has a broken alternator. Need to find a way to test this along with testing the cooling fan. It does not turn on. Other then that, the bike runs and is good.
So yea, I'm just trying to save a few bucks by buying the acid vs new battery especially if I have to buy the other parts as well.
Once I fix those things I will be selling the bike with a rebuild title.
Any help Is much appreciated
David Zmobile: 646.267.1109poisonpartyband.com
![Smile :)](./images/smilies/icon_e_smile.gif)
But wait, he said the battery has no acid in it. What's the full story? Is it *dry*? Was the original acid dumped? Was the battery rinsed? If the plates aren't shot (still lead and clean-ish), maybe it could be resurrected. If it's a matter of all the water evaporating from the original acid, then the battery is toast. Mark On Fri, Oct 7, 2016 at 4:19 PM, salinej1@... [DSN_KLR650] DSN_KLR650@yahoogroups.com> wrote: [u][/u] On Fri, 7 Oct 2016 11:33:59 -0400 "david zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: Hello friends, I have a used 2007 battery that's been sitting without any acid for a few months. Can I just buy the acid, fill up and recharge or do I need to buy a whole new battery? Will it work ok? Regards, -- David Z <><><><><> <><><><><> David, Once a battery has been put into service you only ever add distilled water. So it is time for a new battery. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . ______________________________ ______________________________ [b]How To Fix Your Fatigue (Do This Every Day)[/b] gundrymd.com http://thirdpartyoffers.juno. com/TGL3142/ 57f803c6946733c636b2st04vuc [img]https://ec.yimg.com/ec?url=https%3A%2F% ... EZSxaw--~E[/img]On Oct 7, 2016, at 6:47 PM, Mark Van Horn kl650b2@... [DSN_KLR650] DSN_KLR650@yahoogroups.com> wrote:
-
- Posts: 54
- Joined: Tue Jan 16, 2007 9:37 am
battery question
#ygrps-yiv-96457400 .ygrps-yiv-96457400ygrp-photo-title { OVERFLOW:hidden;FONT-SIZE:smaller;HEIGHT:15px;WIDTH:75px;TEXT-ALIGN:center;CLEAR:both;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400ygrp-photo { BORDER-TOP:black 1px solid;HEIGHT:62px;BORDER-RIGHT:black 1px solid;WIDTH:62px;BACKGROUND-REPEAT:no-repeat;BORDER-BOTTOM:black 1px solid;BACKGROUND-POSITION:center 50%;BORDER-LEFT:black 1px solid;BACKGROUND-COLOR:white;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400photo-title A { TEXT-DECORATION:none;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400photo-title A:active { TEXT-DECORATION:none;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400photo-title A:hover { TEXT-DECORATION:none;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400photo-title A:visited { TEXT-DECORATION:none;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400attach-table DIV.ygrps-yiv-96457400attach-row { CLEAR:both;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400attach-table DIV.ygrps-yiv-96457400attach-row DIV { FLOAT:left;} #ygrps-yiv-96457400 P { OVERFLOW:hidden;PADDING-BOTTOM:3px;PADDING-TOP:15px;PADDING-LEFT:0px;CLEAR:both;PADDING-RIGHT:0px;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400ygrp-file { WIDTH:30px;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400attach-table DIV.ygrps-yiv-96457400attach-row DIV DIV A { TEXT-DECORATION:none;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400attach-table DIV.ygrps-yiv-96457400attach-row DIV DIV SPAN { FONT-WEIGHT:normal;} #ygrps-yiv-96457400 DIV.ygrps-yiv-96457400ygrp-file-title { FONT-WEIGHT:bold;} On Sat, 8 Oct 2016 19:16:37 -0400 "David Zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: The bike was stolen from me and was sitting for a few months. When I got it back there was nothing inside the battery. I filled it up with distilled water, charged it for 3days and the bike fired up. 3 weeks passed. After riding the bike to the DMV Inspection site for a new title the battery died. I jumped it from a car and passed the test.
I'm suspecting that the bike has a broken alternator. Need to find a way to test this along with testing the cooling fan. It does not turn on. Other then that, the bike runs and is good.
So yea, I'm just trying to save a few bucks by buying the acid vs new battery especially if I have to buy the other parts as well.
Once I fix those things I will be selling the bike with a rebuild title. Any help Is much appreciated
David Z <><><><><><><><> <><><><><><><><> David, The first rule for checking charging systems is to start with a known, fully charged and good condition battery. Until you start with that you are wasting time on further investigation. Because of the way the battery works chemically and electrically adding acid to a battery that has gone dry doesn't work. If distilled water and charging doesn't bring it to life the battery should be removed from service and replaced. Just because a battery is new doesn't mean it is good. Once you have a known fully charged battery in good condition check the following and report the results. Make the readings to 0.1 volts, i.e. 12.6 volts or 11.8 volts etc. - Battery voltage at rest at least 3 hours after charging. - Battery voltage after 3 minutes with the key in the on position, headlight on low beam. - Battery voltage 1 minute after turning the key to off. - Battery voltage at idle, one minute after starting the bike. - Battery voltage at 3,000 rpm while holding it there for a timed 20 seconds. Those readings will give you some good data to report and consider. I think you have a Gen I KLR. If that is correct... to test the fan with an energized electrical system... remove the wire from the sensor at the bottom of the radiator. Spin the fan with your finger to prove it spins freely. Touch the wire to the edge of a fin on the head/cylinder. Grounding that wire will complete the circuit and the fan should spin. If it doesn't spin check the 10 amp fan fuse and let us know. Best,
Jeff Saline
The Beautiful Black Hills of South Dakota
75 R90/6, 03 KLR650
. . . . . . . . .
____________________________________________________________
[b]Warning: Don't Diet Before You See This[/b]
gundrymd.com
http://thirdpartyoffers.juno.com/TGL3142/57f99589d7546158940cest03vuc
[img]https://ec.yimg.com/ec?url=https%3A%2F% ... EZSxaw--~E[/img]
![Smile :)](./images/smilies/icon_e_smile.gif)
-
- Posts: 105
- Joined: Mon Mar 14, 2011 10:46 pm
battery question
Hey Jeff,
Thank you for that. It is a Gen 1 2007 klr. I did fill it up with distilled water before and it did hold a charge for a few weeks. However when I took it on a long ride, shut it off and tried to start later the battery was dead. Regardless I will fill up with distilled, charge it up and perform the test you mentioned.
Hope everybody's doing good on this list and getting their bikes ready to ride in the snow!
-David
-- David Z mobile: 646-267-1109 poisonpartyband.comOn Sat, Oct 8, 2016 at 8:54 PM, wrote: [u][/u] On Sat, 8 Oct 2016 19:16:37 -0400 "David Zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: The bike was stolen from me and was sitting for a few months. When I got it back there was nothing inside the battery. I filled it up with distilled water, charged it for 3days and the bike fired up. 3 weeks passed. After riding the bike to the DMV Inspection site for a new title the battery died. I jumped it from a car and passed the test. I'm suspecting that the bike has a broken alternator. Need to find a way to test this along with testing the cooling fan. It does not turn on. Other then that, the bike runs and is good. So yea, I'm just trying to save a few bucks by buying the acid vs new battery especially if I have to buy the other parts as well. Once I fix those things I will be selling the bike with a rebuild title. Any help Is much appreciatedDavid Z <><><><><><><><> <><><><><><><><> David, The first rule for checking charging systems is to start with a known, fully charged and good condition battery. Until you start with that you are wasting time on further investigation. Because of the way the battery works chemically and electrically adding acid to a battery that has gone dry doesn't work. If distilled water and charging doesn't bring it to life the battery should be removed from service and replaced. Just because a battery is new doesn't mean it is good. Once you have a known fully charged battery in good condition check the following and report the results. Make the readings to 0.1 volts, i.e. 12.6 volts or 11.8 volts etc. - Battery voltage at rest at least 3 hours after charging. - Battery voltage after 3 minutes with the key in the on position, headlight on low beam. - Battery voltage 1 minute after turning the key to off. - Battery voltage at idle, one minute after starting the bike. - Battery voltage at 3,000 rpm while holding it there for a timed 20 seconds. Those readings will give you some good data to report and consider. I think you have a Gen I KLR. If that is correct... to test the fan with an energized electrical system... remove the wire from the sensor at the bottom of the radiator. Spin the fan with your finger to prove it spins freely. Touch the wire to the edge of a fin on the head/cylinder. Grounding that wire will complete the circuit and the fan should spin. If it doesn't spin check the 10 amp fan fuse and let us know. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . . . ______________________________ ______________________________ [b]Watch: Alzheimer s Reversal Cocktail Changing Lives[/b] Nutrition and Healing http://thirdpartyoffers.juno. com/TGL3142/ 57f99589d8717158940cfst03vuc [img]https://ec.yimg.com/ec?url=https%3A%2F% ... EZSxaw--~E[/img]
-
- Posts: 105
- Joined: Mon Mar 14, 2011 10:46 pm
battery question
Morning,
Thanks to Jeff and the gang. I found the fuse by the coolant container and
replaced it.
The fan turns on and the bike does not overheat anymore.
Now I have to figure out why the speedometer and the rmp gauge does not
move. I replaced the washer in the wheel by the bearings. Checked the cable
by the speedometer and made sure its plugged in. Ehhh...one day I ll get
there...
Thanks guys!
David
On Mon, Oct 24, 2016 at 10:57 AM, wrote: > David, > > That looks like the Gen I fan wire. When it is touched to ground (the > edge of a head fin works well) the fan should activate. > > In stock configuration there is a 10 amp fuse for the fan circuit on 1990 > and on models. It is located in a white wire on the right side of the bike > behind the right fuel tank shroud. It is wire tied to the coolant bottle > support. > > So if the fan doesn't activate and it does spin easily with your finger > the next check should probably be the fuse. It should have power on both > sides when installed. > > There is also a fan relay in the system that can cause issues. It is the > same relay as the starter circuit relay so you have one already on the > bike you can swap in for testing purposes. > > Check the fan to make sure it spins and if it does spin freely check the > fuse. If that doesn't fix the issue check back (on list is better as more > folks can chime in or learn from what is going on) and you can test the fan > relay operation. > > I'll guess the added wire on the fan chassis is to provide a ground for > the fan motor. If that guess is correct it should be connected at both > ends. > > Do you have a test light or multimeter? > > Best, > > Jeff > > On Mon, 24 Oct 2016 10:35:36 -0400 david zawadzki > writes: > > Hi Jeff, > > Is this the fan sensor wire? It connects to the radiator at the bottom. I > disconnected the wire with the key in the on position, touched it to the > head and the fan did not turn on. Is there any other way to test the fan? > > There is a wire on the side of the radiator that connects with a 10mm > bolt. Should I leave that connected? > > Thank you Sir. > > On Thu, Oct 13, 2016 at 9:56 PM, wrote: > >> David, >> >> I'll suggest before you mess much with the test you just find out what >> the battery voltage is. If it is really fully charged it will be 12.6 >> volts. My guess is the battery is bad and it is fooling the charger into >> thinking it is fully charged. You can also monitor the charging voltage >> and see if the charger runs the battery to 14.4 volts or so. >> >> When you have the battery off the charger record the voltage. Then turn >> the key on and see if the voltage remains about the same. Example for a >> good battery might be 12.6 volts off the charger and then 12.3 volts or >> more with the key on. If you get a reading below 12.0 volts I'll suggest >> the battery at a minimum isn't fully charged and is probably bad. >> >> If that tests ok then maybe continue with the full battery of tests. >> >> You can also take the battery to a battery shop like Batteries Plus or >> Interstate Batteries and they can test the battery. Usually it is free. >> >> A load test is the real test to see if a battery is in good condition. >> >> Good luck, >> >> Jeff >> >> On Thu, 13 Oct 2016 17:24:44 -0400 david zawadzki >> writes: >> >> Hey Jeff, >> >> I filled up the battery with distilled water 2 days ago, plugged it into >> the battery tender and it was fully charged in 10 minutes. Strange. I >> didn't have time to do the full test as of yet but my guess is that its a >> bad battery and here is the reason: >> >> On the way to the dmv inspection I had to turn off the bike every few >> minutes so that the bike does not over heat. Probably killed the already >> bad battery. It's a few years old..and was sitting on a police lot for >> quite some time completely dry.. >> >> When I left the dmv inspection place I jumped the battery from the car. >> Rode it for 40 minutes and the battery got charged up so that's why it only >> took 10 minutes on the tender. >> >> Makes sense no? Anyways I'll do the test. Thanks for listening lol >> >> >> On Sun, Oct 9, 2016 at 3:46 PM, david zawadzki >> wrote: >> >>> Hey Jeff, >>> >>> Thank you for that. It is a Gen 1 2007 klr. I did fill it up with >>> distilled water before and it did hold a charge for a few weeks. However >>> when I took it on a long ride, shut it off and tried to start later the >>> battery was dead. Regardless I will fill up with distilled, charge it up >>> and perform the test you mentioned. >>> >>> Hope everybody's doing good on this list and getting their bikes ready >>> to ride in the snow! >>> >>> -David >>> >>> On Sat, Oct 8, 2016 at 8:54 PM, wrote: >>> >>>> On Sat, 8 Oct 2016 19:16:37 -0400 "David Zawadzki fordavidz@... >>>> [DSN_KLR650]" DSN_KLR650@yahoogroups.com> writes: >>>> >>>> The bike was stolen from me and was sitting for a few months. When I >>>> got it back there was nothing inside the battery. I filled it up with >>>> distilled water, charged it for 3days and the bike fired up. 3 weeks >>>> passed. After riding the bike to the DMV Inspection site for a new title >>>> the battery died. I jumped it from a car and passed the test. >>>> >>>> I'm suspecting that the bike has a broken alternator. Need to find a >>>> way to test this along with testing the cooling fan. It does not turn on. >>>> Other then that, the bike runs and is good. >>>> >>>> So yea, I'm just trying to save a few bucks by buying the acid vs new >>>> battery especially if I have to buy the other parts as well. >>>> >>>> Once I fix those things I will be selling the bike with a rebuild >>>> title. >>>> >>>> Any help Is much appreciated>>>> >>>> David Z >>>> <><><><><><><><> >>>> <><><><><><><><> >>>> >>>> David, >>>> >>>> The first rule for checking charging systems is to start with a known, >>>> fully charged and good condition battery. Until you start with that you >>>> are wasting time on further investigation. >>>> >>>> Because of the way the battery works chemically and electrically adding >>>> acid to a battery that has gone dry doesn't work. If distilled water and >>>> charging doesn't bring it to life the battery should be removed from >>>> service and replaced. Just because a battery is new doesn't mean it is >>>> good. >>>> >>>> Once you have a known fully charged battery in good condition check the >>>> following and report the results. Make the readings to 0.1 volts, i.e. >>>> 12.6 volts or 11.8 volts etc. >>>> >>>> - Battery voltage at rest at least 3 hours after charging. >>>> >>>> - Battery voltage after 3 minutes with the key in the on position, >>>> headlight on low beam. >>>> >>>> - Battery voltage 1 minute after turning the key to off. >>>> >>>> - Battery voltage at idle, one minute after starting the bike. >>>> >>>> - Battery voltage at 3,000 rpm while holding it there for a timed 20 >>>> seconds. >>>> >>>> Those readings will give you some good data to report and consider. >>>> >>>> I think you have a Gen I KLR. If that is correct... to test the fan >>>> with an energized electrical system... remove the wire from the sensor at >>>> the bottom of the radiator. Spin the fan with your finger to prove it >>>> spins freely. Touch the wire to the edge of a fin on the head/cylinder. >>>> Grounding that wire will complete the circuit and the fan should spin. If >>>> it doesn't spin check the 10 amp fan fuse and let us know. >>>> >>>> Best, >>>> >>>> Jeff Saline >>>> The Beautiful Black Hills of South Dakota >>>> 75 R90/6, 03 KLR650 >>>> . >>>> . >>>> . >>>> . >>>> . >>>> . >>>> . >>>> . >>>> . >>>> >>>> >>>> >>>> >>>> >>>> >>>> ____________________________________________________________ >>>> *Watch: Alzheimer s Reversal Cocktail Changing Lives* >>>> Nutrition and Healing >>>> http://thirdpartyoffers.juno.com/TGL3142/57f99589d8717158940cfst03vuc> >>>> http://thirdpartyoffers.juno.com/TGL3142/57f99589d8717158940cfst03vuc >>>> [image: SponsoredBy Content.Ad] >>> >>> >>> >>> >>> -- >>> David Z >>> mobile: 646-267-1109 >>> poisonpartyband.com >>> >> >> >> >> -- >> David Z >> mobile: 646-267-1109 >> poisonpartyband.com >> >> >> >> >> ____________________________________________________________ >> *How To Fix Your Fatigue (Do This Every Day)* >> gundrymd.com >> http://thirdpartyoffers.juno.com/TGL3142/58003b82232153b825f01st03vuc> >> http://thirdpartyoffers.juno.com/TGL3142/58003b82232153b825f01st03vuc >> [image: SponsoredBy Content.Ad] > > > > > -- > David Z > mobile: 646-267-1109 > poisonpartyband.com > > > > > ____________________________________________________________ > *Wait Till You See What She Used To Look Like!* > hooch.net > http://thirdpartyoffers.juno.com/TGL3142/580e21a08a98d21a077e0st02vuc> > http://thirdpartyoffers.juno.com/TGL3142/580e21a08a98d21a077e0st02vuc > [image: SponsoredBy Content.Ad] -- David Z mobile: 646-267-1109 poisonpartyband.com [Non-text portions of this message have been removed]
Who is online
Users browsing this forum: No registered users and 69 guests